The article is presented the relationship of the technical condition of the elements of bearing supports of mining equipment and spectral features based on the analysis of the high-frequency component of the vibrosignal, allowing to determine the type of defects and predict their development. The results of experimental studies of the vibration of the support nodes of mining equipment are presented. Studies have shown a striking gap between complexity and the high cost of operating equipment and the low technological level of its service. Such a gap is one of the main reasons for unscheduled equipment shutdowns, long downtime associated with the detection and elimination of the causes of failures, high repair costs, and emergency situations. Vibration monitoring technology is presented, which uses regular measurements of vibration parameters, their frequency analysis, and mathematical modeling of degradation processes in machines using software packages. For vibration monitoring of mining equipment, provides for control and diagnostic vibration measurements. Control measurements are designed to assess the technical condition of mining equipment as a whole, as well as its individual components. Diagnostic measurements are designed to identify defects, develop recommendations for their elimination and determine the timing of the output of equipment for repair according to the actual technical condition.
| Mualliflar | I. P. Egamberdiev, А.У. Мирзаев, Sh. Sh. Zoirov, Sh. N. Yakhshiev |
|---|---|
| Jurnal | Илм-фан ва инновацион ривожланиш |
| Nashr sanasi | 2020-02-26 |
| Jild | 3 |
| Son | 1 |
| Betlar | 114-119 |
| Til | en |
| DOI | 10.36522/2181-9637-2020-1-14 |
DOI: 10.36522/2181-9637-2020-1-14 · Maqolaning asl sahifasi
The article provides research results on the physiology and biochemistry of the digestion system of termites of the genus Anacanthotermes. It should be noted that the salivary and intestinal enzymes play an important…
The article discusses scientific elaborations on renewable energy sources made by national and international economists. The study evaluates the potential of renewable sources available in Uzbekistan from economic…
The article outlines the theoretical aspects of using the discounted cash flow method to evaluate the capital cost of a joint-stock company with special emphasis on the use of the relative income method used in…
A domestic device designed for the implementation of the hair follicle transplantation procedure was studied for the first time in order to assess the suitability of extractable hair follicles of the donor zone for…
In recent years, due to increasing demand for food, there has been a need to increase crop yield, which is achieved by raising the doses of chemical fertilizers used. Their irrational use leads to serious negative…
The paper examines the determinants of exchange rate fluctuations of Uzbek sum using three econometric models as OLS (Ordinary Least Squares), ARIMA (Autoregressive Integrated Moving Average) and MLARCH (Multivariate…
The article provides recommendations on the results of the analysis of the problems of promoting the Institute of Mediation, enshrined in national legislation (substantive and procedural law) of the Republic of…
The article discusses current and strategic issues of attracting young people to entrepreneurial activity in the process of forming a state youth policy. It deals with the problems associated with increasing…
The article is devoted to experimental research of the major dynamic indicator of soil. The study describes the technique for conducting research on vibrating installation. There are marked changes in the adhesion of…
The socio-economic development of the country, sustainable economic growth, income growth and improvement of living conditions depend on the investment volume and activity. Developing countries adopt policies aimed at…